新合成复合絮凝剂HECES絮凝性能研究

摘要/Abstract

摘要： 以无机铝盐和天然高分子玉米淀粉为原料,合成一种生态安全型复合高效絮凝剂HECES.结果表明,在一定范围里适当提高淀粉/铝盐比例,有利于HECES絮凝性能的提高;处理模拟废水时,3.0mg·L^-1的HECES相当于4.5mg·L^-1PAC和1.0mg·L^-1PAM复合投加效果;对生活污水、市政污水的最佳投加量分别为8.0mg·L^-1和4.0mg·L^-1,相当于PAC用量的50%和40%,浊度去除率高达95%和99%.研究还证实絮凝效果与模拟浊度废水的浓度、供试污水的组成成分有关,HECES对高浓度废水处理效果更佳.HECES在pH=4.0～9.5范围内絮凝效果最佳.其生态安全特点体现在投加量少,具有较大生态毒性的游离态铝离子残留量低.

关键词: 复合絮凝剂, 絮凝性能, 浊度, 污水处理, 生态安全

Abstract: Combined flocculants with higher environmental safty and lower ecological risk are urgently required in the process of water and wastewater treatment. HECES, a kind of flocculants with high effect and high ecological safety was synthesized by natural and biodegradable polysaccharide starch of corn and inorganic aluminium salt. Flocculent performance includes sediment character and turbidity removal rate. The jar test results showed that the flocculent performance of HECES with the dose of 3.0mg·L^-1 was prior to the combined adding4.5 mg·L^-1 PAC and 1.0 mg·L^-1 PAM in treating kaolin suspensions. The optimal concentration of HECES was 8.0 mg·L^-1 and 4.0 mg·L^-1 in treating domestic wastewater and municipal effluent respectively, with the comparison to 50% an40% of PAC, the removal rate of turbidity reached 95% and 99%, respectively. It was also identified that the optimal concentration required to effect flocculation depended on kaolin concentration,and on the character of the wastewater within the range examined. It could be more effective to treat wastewater with higher concentration of HECES. The flocculating performance would be better at pH 4.0～9.5.The superior ecological safety of HECES was due to its lower dosage and its lower concentration of residual activated aluminium.

Key words: Combined flocculants, Flocculent performance, Turbidity, Sewage treatment, Ecological safety

中图分类号:

X703.5

张凯松, 周启星, 魏树和, 任丽萍. 新合成复合絮凝剂HECES絮凝性能研究[J]. 应用生态学报, 2003, (5): 789-793.

ZHANG Kaisong, ZHOU Qixing, WEI Shuhe, REN Liping . Performance of a novel combined flocculant HECES[J]. Chinese Journal of Applied Ecology, 2003, (5): 789-793.

参考文献

[1] Cui F-Y(崔福义),Hu M-C(胡明成),Zhang Y(张燕),et al. 2002. Investigation on aluminum concentration in drinking water in part of China's cities.China Water Wastewater(中国给水排水),18(1): 5～8(in Chinese)
[2] Cui Y-X(崔蕴霞),Xiao J(肖锦). 1998. Alumium salt flocculation agent and its affection on environment.Indus Water Treat(工业水处理),18(5): 6～9 (in Chinese)
[3] Dearfield KL,Abermathy CO. 1988. Acrylamide:its metabolism,developmental and reproductive effects,genotoxicity and carcinogenicity.Mutant Res,195:45～77
[4] Kurenkov VF,et al. 2001.Preparation of anionic flocculant by alkaline hydrolysis of polyacrylamide(Praestol 2500)in aqueous solutions and its use for water treatment purposes.Russian J Appl Chem,74(3):445～448
[5] Lee JC,Kim JS,Kang IJ,et al. 2001. Potention and limitation of alum or zeolite addition to improve the permormance of a submerged menbrane bioreactor,Water Sci Technol,43(11):59～66
[6] Morlay C,Cromer M and Vittori O. 2000.The removal of copper(II)and nickel(II)from dilute aqueous solution by a synthetic flocculant: a polarographic study of the complexation with a high molecular weight poly(acrylic acid)for different pH values.Water Res,34(2):455～459
[7] Poléo ABS,stbye K,xnevad SA,et al.1997.Toxicity of acid aluminium-rich water to seven freshwater fish species:a comparative laboratory study.Environ Poll,96(2):129～139
[8] Shih IL, Van YT. 2001. Production of a biopolymer flocculant from Bacillus licheniformis and its flocculation properties.Bioresour Technol,79(3):207～225
[9] Sun T-H(孙铁珩),Zhou Q-X(周启星),Li P-J(李培军). 2001.Pollution Ecology. Beijing:Science Press.(in Chinese)
[10] Tripathy T,Karmakar NC, Singh R P. 2001. Development of novel polymeric flocculant based on grafted sodium alginate for the treatment of coal mine wastewater.J Appl Polymer Sci,82(2):375～382
[11] Vanhorick M,Morns W. 1983. Carcinogen of acylamide.Carcinogenesis,4:1459～1463
[12] Zhang G,Wang Z. 2000. Mechanism study of coagulant impact on mutagenic activity in water.Water Res,34(6):1781～1790
[13] Zhang K-S(张凯松), Zhou Q-X(周启星), Sun T-H(孙铁珩). 2003. Advances and application of treatment technology for sewage harmlessness and resource fulness in small cities and towns.Eng Sci(中国工程科学), 5(2): 88～92(in Chinese)
[14] Zhou Q-X(周启星), Wang R-S(王如松). 1997. Ecological risk and background warning values of water pollution from rural urbanization.Chin J Appl Ecol(应用生态学报), 8(3): 309～313(in Chinese)

[1]	黄俊杰, 冯秀丽, 董毓伊, 张驰, 谢立建, 程俊恺, 高天宇. 基于遥感生态指数和图论知识的宁波市生态安全格局构建 [J]. 应用生态学报, 2023, 34(9): 2489-2497.
[2]	马扩, 郝丽娜, 童新, 段利民, 曹文梅, 康雪儿, 刘小勇, 刘廷玺. 科尔沁沙丘-草甸相间地区生态安全格局的时空演变 [J]. 应用生态学报, 2023, 34(8): 2215-2225.
[3]	金银丽, 周冬梅, 周凡, 杨静, 朱小燕, 马静, 张军. 疏勒河流域生态安全网络构建及优化 [J]. 应用生态学报, 2023, 34(4): 1063-1072.
[4]	潘卫涛, 岳邦瑞, 姚龙杰, 薛建锋, 李军峰. 耦合风险与服务的市域生态安全格局构建——以陕西省咸阳市为例 [J]. 应用生态学报, 2023, 34(1): 178-186.
[5]	冯碧鸥, 岳文泽, 夏皓轩. 生态安全格局视角下的生态保护红线评估——以浙江省为例 [J]. 应用生态学报, 2022, 33(9): 2466-2474.
[6]	闫玉玉, 孙彦伟, 刘敏. 基于生态安全格局的上海国土空间生态修复关键区域识别与修复策略 [J]. 应用生态学报, 2022, 33(12): 3369-3378.
[7]	王亚军, 司运美, 李彦娟. 群体感应在生物强化功能菌定殖及降解能力增强中的作用研究进展 [J]. 应用生态学报, 2022, 33(10): 2871-2880.
[8]	李晓明, 孙从建, 孙九林, 陈伟, 李新功. 基于遥感信息的黄土高原主要灌溉农业分布区生态安全特征 [J]. 应用生态学报, 2021, 32(9): 3177-3184.
[9]	李涛, 巩雅博, 戈健宅, 齐增湘, 谢水波. 基于电路理论的城市景观生态安全格局构建——以湖南省衡阳市为例 [J]. 应用生态学报, 2021, 32(7): 2555-2564.
[10]	于贵瑞, 杨萌, 陈智, 张雷明. 大尺度区域生态环境治理及国家生态安全格局构建的技术途径和战略布局 [J]. 应用生态学报, 2021, 32(4): 1141-1153.
[11]	郝月, 张娜, 杜亚娟, 王熠辉, 郑艳东, 张长春. 基于生境质量的唐县生态安全格局构建 [J]. 应用生态学报, 2019, 30(3): 1015-1024.
[12]	黄隆杨,刘胜华,方莹,邹磊. 基于“质量-风险-需求”框架的武汉市生态安全格局构建 [J]. 应用生态学报, 2019, 30(2): 615-626.
[13]	李梦娣, 范俊韬, 孔维静, 张远, 迟明慧. 河流山区段水生态安全评估——以太子河为例 [J]. 应用生态学报, 2018, 29(8): 2685-2694.
[14]	彭建,贾靖雷,胡熠娜,田璐,李慧蕾. 基于地表湿润指数的农牧交错带地区生态安全格局构建——以内蒙古自治区杭锦旗为例 [J]. 应用生态学报, 2018, 29(6): 1990-1998.
[15]	林美霞, 吝涛, 邱全毅, 孙彩歌, 邓富亮, 张国钦. 不同类型城市快速扩张区域人工景观对自然景观的生态安全胁迫效应比较 [J]. 应用生态学报, 2017, 28(4): 1326-1336.